Lab Safety

Providing support, in the form of risk assessment, review, consultation(link sends e-mail), training, and the necessary resources and guidance for research at UC Berkeley.

Job Safety Analysis (JSA) Library

Job Safety Analysis (JSA)

A JSA describes job tasks in step-by-step fashion, identifies associated hazards at each step, and outlines proper hazard controls that minimize the risk of injury or illness to the individual(s) performing that task.

Fact Sheets

Fact Sheets

EH&S Fact Sheets serve as campus-wide Standard Operating Procedures (SOP).

Safety Data Sheets

Safety data sheets (formerly MSDS) are the best source of information regarding the hazards, emergency response, and protective measures for any hazardous material.

Manufacturers are always the most reliable sources for SDSs, and the UC system has provided its researchers with UC SDS Resources, a systemwide website created to help locate SDSs and other chemical safety information. In addition,...

Lessons Learned at UC Berkeley

Eddie Ciprazo

Laser Safety Officer
Laser Safety
LUA

Glass Reactor Over-pressurization Causes Serious Injury to Grad Student Researcher

October 31, 2011
Office of Environment, Health, and Safety
What Happened?

A recent lab accident caused serious injury to a UCB graduate student due to an over-pressurization that caused a glass reactor to fail. Glass was sprayed at the researcher who received cuts to his lip, chin, chest, and serious cuts to his hands. 911 was called and the researcher was taken by ambulance to the hospital. The cuts to the hand were serious enough to require stitches and surgery on the palm.

The chemical research involved a toxic/flammable gas that was liquefied and used with a pyrophoric reagent. The reaction was done inside a fume hood, so no one else...

Laser Safety in Research Laboratories

July 31, 2003
Office of Environment, Health, and Safety

In April 2003, the Non-Ionizing Radiation Safety Committee (NIRSC) informed the laser research community that a serious laser eye injury had occurred on the UC Berkeley campus. The campus Laboratory Safety Officer (LSO) performed an investigation of the incident. The following information and lessons learned are based on the LSO’s investigation of the incident.

What Happened?

The incident involved a short pulse, Class 4, invisible (1064 nm), Nd:YAG laser in a multi-user laser laboratory. During alignment of the laser's Nd:YAG beam, a graduate student was struck in the...

Needlestick from Regular Trash

July 31, 2005
Office of Environment, Health, and Safety
What Happened?

An employee in Campus Recycling & Refuse Services was stuck by a needle while emptying trash bags from a dumpster behind Wellman Hall. The incident happened early in the morning, and the employee sought immediate off-site medical care. A physician dispensed antiretrovirals for a possible Human Immunodeficiency Virus (HIV) exposure, and the employee was very concerned that he might have been infected with a life-threatening disease.

The employee’s supervisor had saved the trash bag, and employees from the Office of Environment, Health & Safety (EH...

Fire Hazard with Immersion Water Heaters

September 30, 2005
Office of Environment, Health, and Safety
What Happened?

It is believed that a Cole Parmer Polystat 12002 immersion heater in a University of California, Santa Cruz (UCSC) microbiology laboratory did not shut off as the water level in the plastic bath dropped, allowing the temperature to rise to the point that the bath material ignited. The fire caused extensive damage to the building and shut down research for several months.

What was the cause?

Immersion water heaters/circulators used in plastic tubs (baths) have been associated with laboratory fires at several universities in recent years. When...

Researcher Smells Toxic Fluorine Gas When Changing Out Gas Cylinder

April 30, 2007
Office of Environment, Health, and Safety
What Happened?

Two researchers were changing out a gas cylinder containing a low concentration of fluorine used in an excimer laser. After reconnecting the regulator, researchers opened the cylinder valve, heard a hissing sound, and smelled a pungent odor. They quickly turned off the cylinder valve and reported the incident to their department safety coordinator (DSC). Fluorine is a very toxic and reactive gas, but fortunately, the concentration was dilute, less than 0.1% fluorine. The DSC contacted EH&S and was advised that researchers involved should be medically evaluated because of...